卷材屋面施工工程安全作业交底.doc

内容摘要：
1、 装卸、搬运、熬制、铺涂沥青，必须使用规定的防护用品。所有参加沥青工作的人员必须穿工作服、戴手套、穿翻毛皮鞋并有帆布护盖等，使皮肤不和沥青接触。
2、 熬制沥青的地点不得设在电线的垂直下方，一般应距离建筑物25m以外。沥青、燃料的堆放场地，离锅不小于5m。
3、 熬油前应清除锅内杂质和积水。
4、 熬油必须有人看守，熬油量不得超过锅容量3/4。下班熄火，一定要将余火熄灭，关闭炉门，盖好锅盖。
5、 锅内沥青着火，应立即用铁板盖住，停止鼓风，封闭炉门，熄灭炉火。严禁向燃烧的沥青浇水，应用干砂或湿麻袋灭火。
6、 装运沥青的勺、桶、壶等工具，不得用焊锡，盛油量不得超过容器的2/3。肩挑或手推车，道路要平坦畅通，跳板要支牢，要有防滑措施，绳具要结实。垂直运输时附近12m范围内禁止站人，屋面上的油桶、油壶必须放置平稳。
7、 屋面铺贴卷材，四周应设置1.2m高的围栏，如遇斜屋面周边防护的高度视坡度增高，靠近屋面四周沿边应侧身操作。
8、 遇六级以上大风时，应停止操作。
9、严禁操作人员在酒后进入施工现场作业。
10、每个工人进入施工现场都必须头戴安全帽。
11、班组如果因劳力不足需要再招新工人时，应事先向工地报告。
12、新工人进场后应先经过三级安全交底，并经考试合格后方可让其正式上岗。
13、新工人进场应具有四证，即：职业资质证、身份证、计划生育证和外来人口暂住证
Abstract:
1, loading and unloading, handling, goats, laying asphalt coating, must use the prescribed protective equipment. All participants must wear asphalt work clothes, gloves, clothing and shoes and a canvas cover Fanmao, so that contact with the skin does not and asphalt.
2, endures the asphalt where no bottom in the vertical wires, buildings should generally be 25m from the outside. Asphalt, fuel stack space, away from the pot is not less than 5m.
3, boil remove the pan before the oil impurities and water.
4, boil the oil must be guarded, shall not exceed the pot boil oil capacity of 3 / 4. Flame work, be sure to extinguish embers, close the door, cover the lid.
5, pitch pan fire, immediately cover with iron to stop the blast, closed door, put out the fire. Prohibited the burning of asphalt watering, application of dry sand or wet sacks fire.
6, loading asphalt spoon, barrels, pots and other tools, should not use solder, amount of fuel container shall not exceed 2 / 3. Loaded or cart, flat road to smooth, firm springboard to branch, to have anti-slip, with a rope to be strong. Near the 12m vertical transportation of people within the prohibition of station, the roof on the drums, oiler must be placed stationary.
7, paving roofing membrane, shall be installed around 1.2m high fence around the protection in case of inclined roof height increased as the slope, near the border should be sideways action around the roof.
8, case of 6 or more wind, it should stop.
9, is strictly prohibited operators in the drink to the construction site work.
10, each worker entering the construction site must be wearing helmets.
11 team if the need to move because of a labor shortage of new workers, the report shall be submitted to the site.
12, after the admission of new workers should go through three security correspondent, and pass the examination before they can let the official posts.
13, the new approach should have four cards of workers, namely: professional qualification certificate, identity cards, birth certificates and residence permits