大模外墙板存放、安装工程安全作业交底.doc

内容摘要：
1、 预制外墙板运到现场后，要将起重卡环卡紧后，方可拆开墙板与平板车的连接件，以避免卸车时因平板车停放不平而发生墙板倾倒事故。
2、 墙板应垂直插放于墙板固定架内，严禁依靠其他物体存放墙板，固定架下脚应有可靠的连接固定措施。
3、 插放墙板时应先将板两侧卡好，再摘掉卡环，固定架高度不小于墙板高度的四分之三。
4、 要经常检查固定架的稳定情况，发现问题及时加固，插板架上面应搭设宽度不少于50cm的走道和上下扶梯道，以利操作。
5、 墙板就位前，必须根据设计标高做好抄平，然后根据墙板平面位置就位。
6、 就位后应用花篮卡具卡在横墙板上，预留钢筋要同预埋铁件焊牢，方可摘掉吊环具。
7、 进入施工现场人人都应正确佩戴安全帽。
8、 高空作业应自觉系好安全带。
9、 严禁酒后上班及带病坚持上班。
10、进入施工现场必须遵守公司的各种安全生产规章制度。
11、如有新工人进场班组长应马上报告工地，经过三级安全交底后和考试合格后方可上岗。
12、班组引进新工人时，应检查新工人的四证，即：职业资格证书、身份证、计划生育证、外来人口暂住证，证件不全者不得接收。
13、 禁操作人员在酒后进入施工现场作业。
14、每个工人进入施工现场都必须头戴安全帽。
15、班组如果因劳力不足需要再招新工人时
Abstract:
1, prefabricated wall panels arrived at the scene, to lift clasp clamping, before open the wall and the flatbed of the connector, in order to avoid unloading flatbed parked due to uneven wall and dumping incidents occurred.
2, wall panels should be placed on the wall bracket vertically inserted within the storage wall is strictly prohibited by other objects, fixation scraps fixed measures should be reliable connection.
3 wall should be put first plate inserted on both sides of card is good, then take off card ring fixator height of not less than three-quarters of wall height.
4, should always check the stability of fixation, identify problems and timely reinforcement, erection flapper frame width should be not less than 50cm above the aisle and up and down escalators Road to facilitate the operation.
5, wall panels in place before, must be good copy for elevation level, flat position and then place under the wall.
6, place flowers fixture card after the application of horizontal wall, the reserve should be reinforced with embedded iron weld before take off rings with.
7, into the construction site that everyone should wear a helmet.
8, high-altitude operations should be consciously seatbelts.
9, non-work drink at work and sick persist.
10, entered the construction site must comply with various safety regulations.
11, if the new workers entering the site team leader should be reported immediately, after three safety classification of components and post-examination only after induction.
12 team to introduce new workers, new workers should check the four cards, namely: professional qualification certificate, identity card, birth certificate, residence permits, were not receiving necessary documents.
13, forbidden operators in the drink to the construction site work.
14, each worker entering the construction site must be wearing helmets.
15 team because of a labor shortage if new workers need to move